您現在的位置：茄子视频下载App → 新聞資訊 → 超聲資訊

臺式超聲波清洗機的保養方法有哪些

日期： 2019-04-27

瀏覽次數: 667

來源：

作者：

發布日期： 2019-04-27

瀏覽次數： 667

正規的臺式超聲波清洗機作為最常用的超聲清洗機，它的出現讓人們對其連連稱贊，因為該高科技產品給人們帶來了顯著的好處，因此在很多領域都能看到它的運用。然而臺式超聲波清洗機如果不能保養得當，那么其使用壽命也會相應的縮短，所以及時進行保養是必不可少的。關于臺式超聲波清洗機的保養方法大致如下：

臺式超聲波清洗機的保養方法有哪些

1、首先應該把可信的臺式超聲波清洗機安放在平穩通風之處，每次注水和排水及保養臺式超聲清洗機時應當關閉電源，用完也需要及時拔掉插座。

2、做好職業防護。每日操作完畢臺式超聲波清洗機，需要用清潔擰干的軟布擦拭儀器表面和內腔，并且除銹除垢時應戴耐酸堿手套。一定要注意避免使用鋼絲球或硬質刷子擦拭，以免對臺式超聲清洗機造成損傷。

3、定期去除臺式超聲波清洗機內腔的水垢和銹跡，除垢劑或除銹劑的配制比例應嚴格按照使用說明，并按照除垢除銹的相關流程：關閉電源→將內腔水排盡→關閉排水閥→用相應比例除垢劑或除銹劑溶液擦拭→用清水將除垢劑或除銹劑沖洗干凈→積水排盡后用清潔擦布擦干。

4、定期檢查臺式超聲波清洗機的閥門工作是否正常，檢查方法參照廠家說明，如果發現臺式超聲清洗機異常，就需要及時匯報或及時聘請專業人員進行維修。此外還需要每年對儀器的溫度傳感器等進行校準（由專業維保人員完成）。

以上皆為保養臺式超聲波清洗機的常用方法，如果用戶嚴格按照以上幾點來操作，那么就能有效延長臺式超聲波清洗機的使用年限，也能最大程度的減少一些維修成本。所以掌握一些維護保養技巧對每個用戶而言都是百利而無一害的。

上一篇：實驗室超聲波清洗器的優勢有哪些？下一篇：臺式超聲波清洗機的常見故障與解決方法

相關新聞 / News More
超聲波清洗機對比人工清洗好在哪里？

點擊次數: 49

2021 - 08 - 11

當人們沒有發明超聲波清洗機時，清洗東西的方法是手動清洗，但是當手動清洗時，會有許多塵垢不易清洗，有些裂縫不能清洗。這不僅添加了工人的作業量，而且大大下降了作業效率，但是在超聲波清洗機出現后，解決了手動清洗引起的這些問題。以下是關于這些區域中超聲波清潔優于手動清潔的長處。1.清潔作用好。超聲波清洗機不僅能夠替代手藝洗手，還能夠滿意手藝洗手的要求。即使是蒸汽清洗和高壓水射流也不能滿意一些外表不平坦，盲孔小（如針尖）和清潔度要求高的儀器。超聲空化還加快化學反應并加快外表膜的溶解。清潔作用更徹底。2.清潔效率高。傳統的手動清潔需求多酶浸泡，手動沖洗，沖洗或用刷機清洗一些瓶子。能夠說需求時刻和精力，人為要素的影響不能保證清洗設備的質量。運用超聲波清洗機時，將清洗設備浸泡在多酶清洗液中，然后直接放入清洗槽中，按份額放入清洗劑中。設定溫度和時刻后，清潔作業可自動開始。3.健康與安全。超聲波清洗機是一種無污染的設備，整個過程是純物理清洗過程，安全可靠，不產生電磁波和輻射，對人體無害。此外，清潔液直接清潔，消毒和消毒醫療機械，消除二次污染，無需人體觸摸清潔液。超聲波清洗機還能夠有效地隔離細菌和病毒，維護家庭成員的安全和健康。在運用超聲波清洗機時，雖然其清洗作用一直很好，但在某些作業范疇要進步效率，就要最大限度地進步其清洗條件，以達到最佳作用。因此，一些細節要素能夠使超聲波清洗機的清洗作用更加出色，如果能夠找到原因并從中開始，則清洗作用會得到明顯進步。超聲波清洗機的清洗作用在洗滌液中的那些氣體的含量也遭到必定程度的影響。如果清潔溶液中存在殘余氣體（非空心），則聲傳輸損耗將隨時刻添加。別的，在空化氣泡運動過程中氣泡的氣體分散將在必定程度上下降沖擊波的強度，并在空化氣泡破裂時削弱清潔作用。因此，在一些具有脫氣的超聲波清洗設備中，在啟動時，榜首功率水平需求低于振蕩閾值，脈...
超聲波清洗機有哪些優缺點？

點擊次數: 46

2021 - 08 - 09

超聲波清洗機相信大家都知道吧，就算沒有用過，至少也有所耳聞。超聲波清洗機無論是在工業方面還是在家用方面都有應用的地方，它被廣泛的使用自然是因為有它獨特的優點，當然，它也有一些不足的地方，下面固特超聲小編就來說說超聲波清洗機的優缺點。優點1、清洗效果好超聲波清洗單論清洗效果方面就是最好的之一，尋常的清洗方式，比如高壓噴射水洗、溶液清洗、蒸汽清洗等都難以達到超聲波清洗的清洗效果。2、清洗全面無死角超聲波清洗機最大的特點之一，工業或者生活中的清洗物大多數外形都是不規則的，要么有難以清洗到的角落，要么就是有孔洞之類的，常規的清洗方式很難清洗得全面。而超聲波清洗機就可以解決這個問題，由于超聲波清洗機的原理是超聲波在水中的空化效應完成的，只要水能達到的地方都可以清洗。3、清洗成本低能做到清洗全面的清洗方式并不是只有超聲波清洗一種，比如溶液清洗也能做到，但是溶液清洗的成本較高，而且不能清洗效果相對較低。超聲波清洗機在兼顧清洗效果和清洗全面性的同時，清洗成本也比較低，通常只有設備成本和用電成本而已，加清洗劑也只需要加少量即可。除此之外，超聲波清洗機的操作簡單，清洗量也不算小，在人力成本上也節約了不少。缺點1、噪音 超聲波清洗機工作時由于諧波等原因噪音比較大且刺耳，這個噪音和頻率、功率有關，頻率越接近人耳的聽力范圍則噪音越大。不過還好，目前市面上有少數品牌可以做到靜音效果，雖說不是真正的靜音，但是噪音的影響會小很多。2、清洗范圍畢竟有限 超聲波清洗機只適用于能放入清洗機內的物品清洗，而且為了保證清洗效果，最好將物品拆分后再清洗。另外，超聲波清洗機不適合清洗軟的物質，比如衣物之類的，這類物品會大大影響清洗效果。3、可能會損傷物品 超聲波空化效果太強的話容易對某些物品造成損傷，比如鍍膜眼鏡或者電鍍的工件等。...
超聲波清洗機對人身體會有傷害嗎？

點擊次數: 28

2021 - 08 - 06

超聲波清洗機的使用，一直以來既受到廣泛的應用，也備受質疑。有人說超聲波清洗機有一定的輻射，對人體會造成傷害。長久以來對身體是很不好的;所以盡量不要身體處于清洗設備的上面，因為超聲波是底部往上走的;一般而言，它的使用對于人的影響并不大。超聲波的傳輸需要介質，普遍的是水，所以通常我們會在超聲波清洗機的水槽里加水。相對于有傳播介質而言，超聲波在空氣里傳播的衰減率最大，因此超聲波對人體的并不會有多大的影響。具體總結為以下四個方面：第一方面：雜音。一般清洗機的雜音有60分貝以上（根據頻率和功率變化），會讓人產生煩躁、不安的情緒,操作久了是非常難受的！！其實超聲波你是聽不到的，你聽到的是清洗作用時與水 于槽體發出的聲音！！操作久了對聽力 還是有影響的，在清洗房說話的 基本都是大嗓門，小嗓門別人根本聽不見。不過，使用鼎泰的靜音型超聲波清洗機就可以解決這個問題了。第二方面：穿透力。超聲波的穿透力是非常強的，你在茶杯里放上水，把茶杯放到清洗槽里，杯里的水和槽體的水不接觸，照樣你杯子里的水有很強的空化作用（超聲波清洗的原理），而且孕婦去醫院照B超，那就是超聲波，因為穿透力是很強的！穿透力強了一會會是沒什么影響，長時間呆在機器旁 對身體肯定不好！第三方面：空化作用，(液體中爆破）。超聲波在清洗的槽的水里能夠有空化作用，能在水里爆破，那么它在你身體里，照樣是會有空化作用。也就是它穿過你的身體，一樣在你體液里清洗！！這就結合到危害二說的穿透力很強了，泄露的超聲也會作用在工作人員的皮膚上，從而改變人體的熱量平衡，影響新陳代謝，而至血液循環。當然了，國家有標準，如果達標的話，那點超聲對人體沒有太大的影響，可以忽略不計，不過強烈建議，孕婦遠離。第四方面：清洗劑。現在清洗藥水基本都是化工產品！雖然現在基本已經淘汰溶劑清洗（揮發的洗劑如三氯甲烷，洗板...
超聲波清洗機配件有哪些？

點擊次數: 79

2021 - 08 - 03

超聲波清洗機主要由超聲波發生器、換能器及其它的輔助系統等八大配件組成。1、其中發生器是相對于機器本身而言是比較重要的配件之一，超聲波發生器將工頻電轉變成28KHZ以上的高頻電信號，通過電纜輸送到換能器上。一般超聲波換能器是固定在清洗槽的底板上，清洗槽內裝滿了液體，當換能器被加上高頻電壓后，它的壓電陶瓷元件在電場作用下便產生縱向振動。2、超聲波換能器（又稱聲頭）是一種高效率的換能元件，能將電能轉換成強有力的超聲波振動，在產生超聲波振動時，仿佛是一個小的活塞，振幅很小，約只有幾微米。但這個振動加速度很大（幾十至幾千個）；槽上具有許多個換能器，施加相同的頻率及相位的電能時，就合成了一個巨大的活塞進行往復振動，這種振動的現象，就是平時我們所說的超聲波。3、加熱及溫度控制系統：加熱器采用鑄鋁加熱片，可耐酸堿，壽命長。加熱的目的是將清洗劑加熱以增加清洗機的洗滌效果，溫度自動控制，可在適當范圍內隨意調整。4、清洗槽：清洗槽采用SU304不銹鋼經氬弧焊焊制而成，槽體上設置有排渣檢修口、保溫隔聲層等。5、槽液循環過濾系統：在該系統中設有過濾器，對槽液進行動態過濾，以維持槽液的清潔度。當工件出槽，經過過濾的液體流經槽體上部的噴淋環節對工件進行一次沖洗，以便沖掉工件出槽，以避免其對下道槽液造成污染。6、輸送系統：根據被清洗工件的形狀、體積、批量等確定超聲波清洗機的輸送方式及控制方式。典型的輸送方式有——懸鏈、網帶、雙鏈、步進、電葫蘆、自行葫蘆、滾筒、轉盤、龍門架、機械手、吊籃、推盤等等。7、噴淋漂洗系統：根據被清洗工件的表面狀況，有的清洗機配備噴淋漂洗工序，將超聲波清洗和噴淋清洗有機地結合起來。8、烘干系統：根據被清洗工件的狀況，有的清洗機配備烘干系統，烘干系統主要由加熱器、風機、吹風噴嘴等組成，溫度自動控制。以上是廣東固特超聲股份有限公司小編為大家作解答的幾點。超聲波...
單槽超聲波清洗機的使用方法及事項

點擊次數: 72

2021 - 08 - 01

單槽超聲波清洗機是運用空化作用成倍或十幾售地提高清洗效果。當把液體放入清洗機內，施加后，由于超聲波在清洗液中是一種疏密相間，輻射傳播的高頻波，從而使液體高速往復振動。在振動的負壓區由于周圍的液體來不及補充，形成無數的微小真空氣泡，而在正壓區，微小氣泡在壓力下突然閉合，在閉合過程中由于液體間相互碰撞產生強大的沖擊波形成可達幾千個大氣壓的瞬時高壓，作用在被清洗的工件上。吸附在工件上的油膩、雜質在連續不斷的瞬時高壓作用下迅速脫離工件。從而達到清潔目的。單槽超聲波清洗機的使用方法：1.需要清洗的物品放入單槽清洗機的清洗籃中，然后將清洗籃放入清洗槽，不可將物品直接放入清洗槽里，避免損壞設備及清洗效果。2.根據不同的產品或者清洗效果，按比例倒入清洗液，水或者水溶液，水位低不得低于60mm,而高不得超過80mm。3.接入220V/50Hz電源三芯插座，接通電源。4.打開單槽超聲波清洗機開關按鈕，綠色開關亮顯示正常工作。5.按照物品的清洗要求，打開超聲波清洗機溫度控制進行溫度調節。6.溫度指示燈熄滅加熱器達到所要的要求，加熱器會停止工作，若低于設置的溫度，加熱器則會繼續自動加熱。7.當加熱溫度達到產品清洗要求時，可以開啟清洗定時器，根據產品清洗要求設置定時器的工作時間。8.一般物品清洗在10分鐘至20分鐘，對于很難清洗的工件，可以適當延長清洗時間，保障清洗效果。9.定時器位置可在1-20min內任意調節，也可調在常通位置。一般清洗在10~20min,對于特別難清洗的部件，可適當延長清洗時間。10.清洗結束清洗槽取出清洗籃用溫水清洗或者在另外一個沒有溶劑的溫水清洗槽里漂洗。11.物品清洗完要進行干燥、存放組裝。單槽超聲波清洗機的注意事項：為了延長使用壽命，建議將設備放在通風、干燥的區域，發生器后側的風扇孔應定期清潔。發生器四面留有通風口，以使氣流暢通無阻。1、清洗槽必須放入液體后才能開機工作...
一臺超聲波清洗機可以用多久？

點擊次數: 49

2021 - 07 - 29

按道理來說工業超聲波清洗機的設計壽命至少是可以使用10年以上的，現在市場上很多魚龍混雜的品牌，冒充自己是廠家的店鋪，這種機器就要您擦亮眼睛辨別清楚，特別就是采購好幾臺的客戶，不妨可以去了解考察，了解清楚這廠家是否正規的。關于超聲波清洗機的報價問題，有些廠家報價一個比一個低，但是相對而言，市場上都是一分錢一分貨，便宜不能說他不好，只會說沒那么好。畢竟是要長期使用的產品，要考慮成本，到了1年維修費加起來都可以買一臺好的機器，而一線品牌的超聲波清洗機能用5-10年以上。現在市場上超聲波清洗機的價格也讓很多客戶難以把控，看起來大小一樣的機子，價格有的高有的低，有幾百塊的也有上千塊。對于超聲波清洗器的價格，固特超聲小編覺得其實主要還是看清洗機器的原材料質量好不好、制造工藝有沒有迭代更新、以及售后服務有沒有保障。有售后保障的廠家會在機器出現問題的時候給予正確的引導，及時為用戶維修出故障的機器，以延長的清洗器的壽命。一臺超聲波清洗機一般弄夠用10年以上是正常的，不過中途可能也有人為使用不當，需要維修之類的這個不排除。畢竟超聲波清洗機也是一種技術，很多人也是第一次接觸這種設備，使用過程中感覺有點復雜，所以良好的售后服務這個才是關鍵，多花點錢選個好品牌，多買一個保障。
超聲波清洗機到底是如何工作的？

點擊次數: 55

2021 - 07 - 28

“超聲波清洗機到底是怎么工作的？”相信很多第一次接觸超聲波清洗機的客戶都會有這樣的疑問，下面固特超聲小編就給大家分享一下超聲波清洗機的相關知識。超聲波作用于液體時可產生大量小氣泡。一個原因是液體內局部出現拉應力而形成負壓，壓強的降低使原來溶于液體的氣體過飽和，而從液體逸出，成為小氣泡。另一原因是強大的拉應力把液體“撕開”成一空洞，稱為空化。超聲波清洗機就是利用“空化效應”來進行清洗的。當然，我們清洗的主要目的是達到清洗需求，解決工件清洗難題。在使用超聲波清洗機清洗的過程中，由于超聲波的頻率很高，在液體中出現“空化”現象所產生的氣泡眾多且無所不在，只要能充分接觸到溶液中，就可以得到徹底的清洗。總體來講，超聲波清洗設備是清洗效率很高的一種清洗設備，尤其是一些精密的部件及隙縫或者死角比較多的物件，超聲波清洗機可以全方位無死角的將其清洗干凈，使物件的表面煥然一新。很多的生產行業中遇到的清洗難題，在使用超聲波清洗機后，都會得到很好的清洗效果。超聲波清洗機設備解決了眾多工業客戶的清洗難題，成為了工業清洗的“寵兒”。
關于超聲波清洗機的原理

點擊次數: 39

2021 - 07 - 26

原理全自動超聲波清洗機原理主要是將換能器，將功率超聲頻源的聲能，并且要轉換成機械振動，通過清洗槽壁使之將槽子中的清洗液輻射到超聲波。由于受到輻射的超聲波，使之槽內液體中的微氣泡能夠在聲波的作用下從而保持振動。當聲壓或者聲強受到壓力到達一定程度時候，氣泡就會迅速膨脹，然后又突然閉合。在這段過程中，氣泡閉合的瞬間產生沖擊波，使氣泡周圍產生1012-1013pa的壓力及局調溫，這種超聲波空化所產生的巨大壓力能破壞不溶性污物而使他們分化于溶液中，蒸汽型空化對污垢的直接反復沖擊。一方面破壞污物與清洗件表面的吸附，另一方面能引起污物層的疲勞破壞而被駁離，氣體型氣泡的振動對固體表面進行擦洗，污層一旦有縫可鉆，氣泡立即'鉆入'振動使污層脫落；由于空化作用，兩種液體在界面迅速分散而乳化，當固體粒子被油污裹著而粘附在清洗件表面時，油被乳化、固體粒子自行脫落，超聲在清洗液中傳播時會產生正負交變的聲壓，形成射流，沖擊清洗件；同時由于非線性效應會產生聲流和微聲流，而超聲空化在固體和液體界面會產生高速的微射流，所有這些作用，能夠破壞污物，除去或削弱邊界污層，增加攪拌、擴散作用，加速可溶性污物的溶解，強化化學清洗劑的清洗作用。由此可見，凡是液體能浸到且聲場存在的地方都有清洗作用，其特點適用于表面形狀非常復雜的零件的清洗。尤其是采用這一技術后，可減少化學溶劑的用量，從而大大降低環境污染。
小型超聲波清洗機有哪些優點？

點擊次數: 71

2021 - 07 - 25

小型超聲波清洗機有多種模式，可以根據不同的物品選擇不同的清洗方法。總的來說，它的容量可以滿足基本要求，可以輕松浸泡，無障礙清洗。小型器件可以全身浸泡，可視化操作眼見為實，使污垢剝離更快。小型超聲波清洗機的優點:第一，多場景清洗 傳統的清洗設備大多需要根據大小混合清洗所有物品，而小型超聲波清洗機則不是。它的物體在清洗時可以分為不同的類別。由于物體的屬性不同，分類清洗可以更有效率。各種清洗模式為不同的物體量身定制清洗模式，如眼鏡、3d太陽鏡、老花鏡等。選擇柔軟的清洗模式;項鏈、手鏈、胸針、耳環、玉鐲、戒指發飾等。選擇強大的經濟模式;再比如珍貴的手表、陶瓷表帶、鋼鏈表帶等。，可以選擇維護和清洗模式。小型超聲波清洗機的多重清洗模式使不同的物品在清洗時更加安全。第二，清洗效果好 很多人認為銷量好的小型超聲波清洗機只能清洗物品表面的浮塵，從表面上看變得清澈透明。比如以眼鏡鏡片為例，小型超聲波清洗機可以清洗表面，眼鏡布很難擦除鏡片的油脂和污垢，尤其是鏡架和鏡片之間的接縫處。小型超聲波清洗機可以在細節上清洗，再比如佩戴久了首飾就暗淡無光。放入小型超聲波清洗機，可以剝離污垢，恢復其光澤。一般來說，小型超聲波清洗機采用超聲波技術，在真空爆破的作用下，可以輕松清洗物品凹槽和死角處的縫隙和污垢。它的振頻極其合適，這是護理的關鍵。振頻可以在不損壞物體的情況下清除其表面和間隙的污垢，避免了振頻過低、清洗不干凈、振頻過高物體易損的弊端。配合清洗劑使用，尤其是油脂和污垢。
使用超聲波振蕩器時注意事項

點擊次數: 115

2021 - 07 - 23

現代企業生產普遍追求高質量，超聲波振蕩器作為一門先進的生產技術，被廣泛地應用于穿透式清潔以及一些較為復雜的幾何結構中，它的清潔效果得到了廣泛的認可。作為一種重要儀器，專業的超聲波振蕩器在使用過程中有一些事項需要注意。超聲波振蕩器的使用注意事項（1）在清洗槽內無清洗液的情況下不允許接通電源打開超聲波振蕩器，并且機器里液面的高度不得低于槽深的三分之一（2）在使用人員從未使用過超聲波振蕩器時，應首先選擇一個物件和一定量的清洗液做一下實驗，避免出現問題。待調整出合適的時間、功率、頻率和清洗劑的種類之后再進行大量清洗，從而達到最好的清洗效果。（3）清洗精密或貴重的物件時，應先將本儀器用純水或是蒸餾水漂洗一段時間，將儀器出廠時所用的保護劑清除掉，然后才能進行物件的清洗。（4）如果清洗的物件是精密的零件，在使用超聲波振蕩器進行清洗工作時，應先逐個清洗并在清洗后立即上油（5）選擇合適的清洗劑： a.超聲波振蕩器禁止直接使用強酸與強堿，易燃易爆易揮發的溶劑； b.使用帶揮發性的溶劑，需要有人看守； c.正常情況下，儀器連續工作15min后會升溫，應注意所選用清洗劑的溫度要求，大部分的清洗劑是不超過60℃，以免超溫后效果不佳甚至會有意外發生； d.特殊清洗劑如不能接觸清洗槽，可間接清洗，即在清洗槽內放入清水，另外用合適的容器放入清洗劑和物件，整個容器在放在槽內的網架上，同樣也可以超聲清洗。不論是評價高的超聲波振蕩器，還是一般的，使用時必須要遵循相關的事項，才能最大限度地增加儀器的使用壽命，保持其處于一個良好運行的工作狀態，進而降低企業在維護保養方面上的成本，最終使企業獲益。

茄子视频下载App

臺式超聲波清洗機的保養方法有哪些

QQ設置

SKYPE 設置

阿里旺旺設置

服務熱線

二維碼(ma)管理